Updated September 2, 2022
Galvanization is the process of applying a protective zinc coating to steel or iron, in order to prevent rusting. The term is derived from the name of Italian scientist Luigi Galvani.
Galvanized steel plumbing pipes are pipes made of steel, and coated with zinc to prevent rusting. This is commonly done by dipping the pipes in a molten zinc bath. These pipes and fittings were commonly installed in homes prior to 1950 (some sites say it was used until the 1960s). Over time, the galvanized steel pipes begin to rust or corrode from the inside out, resulting in reduced water pressure and restricted water flow. This presents an increased risk of leaks or ruptures occurring in the pipes and the potential for flood damage. Corrosion also occurs to steel when it is connected directly to copper or brass.
Galvanized steel pipes have an average life expectancy of 40 to 50 years. Since these have not been installed since, at the very latest, the 1960’s, these would all have passed their expected lifespan. If your supply lines are made of galvanized steel, there is constant water pressure pushing the water towards the faucets, placing pressure on the corroded pipes. If your waste lines are made of galvanized steel, there is less pressure on them, as the waste liquid is just flowing out of the home, and the lifespan may be a bit longer.
Galvanized steel will corrode over time, and it is almost impossible to tell this is happening just by looking at the pipes from the outside. The pipes rust away from the inside out, causing weak structural properties resulting in leaks and collapses. They will also develop calcium deposits inside of the pipe. These pipes can eventually become completely clogged with calcium build-up resulting in low water pressure and rusty water.
Watch for these tell-tale signs to spot issues before the galvanized steel pipes begin to leak or even rupture:
Unfortunately, if you are experiencing issues with your galvanized steel pipes, the best remedy may be completely replacing the galvanized plumbing that has been affected. According to Cost Helper, the cost to replace galvanized steel plumbing in the average house ranges between $1,500 and $15,000.
The service lines, which connect your home’s plumbing with the water main, are normally made of copper. However in older cities in the Eastern parts of the US and Canada, may still have service lines made of lead. Many homes have had this lead service pipe removed and upgraded with modern plumbing material, however for homes that had galvanized plumbing while their lead service lines were in-place there exists another area of concern. Galvanized piping has been found to accumulate lead that has leeched into the water from the old lead service lines. As the galvanized plumbing corrodes (as it inevitably will do), it releases this built up lead back into the water.
Insurance companies will want to know exactly what type of plumbing you have in your home. If you’re not sure, there is an easy way to check. Find where the piping enters your home and then scratch it. If the piping is:
If you have galvanized steel plumbing, your insurance company may require you to have it replaced with copper or plastic piping before providing coverage. Or they may increase your water damage deductible or limit the amount of coverage provided.
ready for an online quote? Policies start at $12/month if you rent your home and $40/month if you own your home. To see how much you can save with Square One, get a personalized online quote now.
Typically, home insurance policies include coverage for any sudden or accidental escape of water in your home, including ruptured water lines, or overflowing appliances. This is why insurance companies ask what type of plumbing you have in your home. They need to be able to accurately assess the risk in order to charge the right rates and provide you with the right coverage. Sometimes, depending on your plumbing situation, a company may not be able to insure you at all, and you’ll need to shop around, and likely pay a higher rate, if you can find coverage at all.
Don’t let this tempt you to tell a little white lie to your insurance broker. This can be construed as “misrepresentation” and can void your policy when it is discovered. Your best course is to always tell the truth. If you discover that the only solution is to replace your plumbing, the expense will be a lot less than finding out, after a loss, that you have no insurance coverage.
When you have a home insurance policy in place, remember that there are always exclusions and limitations. It is extremely important to read your policy wording, with an emphasis on any water exclusions. You can contact your insurance agent or broker if you have any questions. In most cases, there is a requirement that you either shut off your main water supply or arrange to have your home checked daily if you are going to be away more than a few days during the winter. If you fail to do this, damage caused by frozen or burst plumbing may not be covered. The requirements differ from one company to the next, so before you go away on vacation, you would be wise to give your broker a call to make sure you’re complying, and that coverage will be in place.
Know exactly what type of plumbing you have, especially if your home is older. Life expectancies vary, and as mentioned above, your insurance company will want an accurate picture of the risk they’re taking on. If your plumbing is past its “best before” date, you could be at risk of leaks, or even worse, bursting pipes.
Check the grout in your bathroom. Water can leak through any small cracks, resulting in dampness behind the wall. This can lead to rot or mold, which is never a good thing.
Think about installing a leak protection device on your plumbing system. Some of these can actually shut off the water when it senses an inappropriate flow.
Scout out any water in the basement after a big rain. If you see water anywhere, it could be because your foundation has some small cracks. You may need to make some repairs, or it could be time to install a sump pump. Maybe your window wells aren’t draining properly, and water has come in through the basement windows. This can be a fairly simple fix, so add this to your maintenance checklist.
Check any water supply hoses on your appliances, such as washing machines or dishwashers. They usually come with rubber hoses that get brittle and crack as they get older. These can be replaced with stainless steel braided hoses, even if you haven’t yet spotted any cracks or other signs of wear. Keep in mind that all hoses have a life expectancy, so check with the manufacturer.
Store valuable possessions high up on shelves, not in boxes on the floor.
Want to learn more? Visit our Getting to Know Your Home resource centre for the complete rundown on all your home's systems and features. Or, get an online quote in under 5 minutes and find out how affordable personalized home insurance can be.
Get a personalized online home insurance quote in just 5 minutes and see how much money you can save by switching to Square One.
Even when you take precautions, accidents can happen. Home insurance is one way to protect your family against financial losses from accidents. And, home insurance can start from as little as $12/month.